Selective Iron Suppression through Sulfation, Oxidative Calcination, and pH-Controlled Atmospheric Leaching of a Ferruginous Oxidized Copper Ore

Vol 9 No 7 (2026): Volume 09 Issue 07 July 2026

Article Date Published : 30 July 2026 | Page No.: 4155-4175 | Google Scholar | Crossref doi for this article

Abstract :

Iron-rich oxidized copper ores are challenging to treat by atmospheric leaching because iron oxides and oxyhydroxides may consume acid and increase impurity loading in the pregnant leach solution. This study evaluated a three-stage route comprising sulfuric-acid sulfation, oxidative calcination, and pH-controlled atmospheric leaching, with the primary objective of minimizing net Fe transfer rather than maximizing Cu extraction. Six distinct operating conditions were investigated using a ferruginous oxidized copper ore from northern Bahia, Brazil, containing 19.6 wt.% Fe, 5.37 wt.% Al, 1.47 wt.% Mg, 0.524 wt.% Mn, and 1.05 wt.% Cu. Commercial sulfuric-acid solution additions during sulfation ranged from 9.75 to 99.69 kg solution/t dry ore. The sulfated products were calcined through staged temperatures from approximately 250 to 700 °C over 6 h and subsequently leached at approximately 90 °C for 180 min, with final solution pH values of 2.33–2.77. Reconciled Fe transfer remained between 0.026% and 0.340%, corresponding to Fe suppression of 99.66–99.97%. By contrast, Mg, Mn, and Al transfers ranged from 6.39% to 29.78%, 38.14% to 59.98%, and 6.95% to 16.28%, respectively, confirming that Fe suppression did not result from a general inhibition of mineral dissolution. The measured Fe transfers corresponded to calculated stoichiometric acid equivalents of only 0.13–1.76 kg H₂SO₄/t ore, compared with an upper-bound requirement of 516.34 kg H₂SO₄/t ore for complete conversion and dissolution of feed Fe as Fe(III) sulfate. The response is consistent with initial formation of ferric sulfate, basic ferric sulfate, or related Fe-bearing sulfate intermediates, followed by thermal destabilization to poorly soluble Fe(III)-oxide-bearing phases and release of sulfur oxides. Released SO₃ may have promoted sulfate redistribution to neighboring reactive metal–oxygen sites, while controlled-pH leaching was consistent with an additional aqueous Fe-rejection barrier through limited Fe-oxide attack and Fe(III) hydrolysis or reprecipitation. Mg behaved as a persistent sulfate sink, Mn showed redox-sensitive transfer, and Al exhibited intermediate behavior. The route therefore selectively decoupled the large Fe inventory from the final aqueous products. Direct-leaching controls and stage-resolved mineralogical, sulfur-speciation, and off-gas analyses are required to quantify actual acid savings and confirm the proposed mechanism.

Keywords :

atmospheric leaching, ferruginous oxidized copper ore, oxidative calcination, pH-controlled leaching, Selective iron suppression, sulfuric-acid sulfation

References :

  1. Bian, Z.-Z., Feng, Y.-L., & Li, H.-R. (2020). Extraction of valuable metals from Ti-bearing blast furnace slag using ammonium sulfate pressurized pyrolysis–acid leaching processes. Transactions of Nonferrous Metals Society of China, 30(10), 2836–2847. https://doi.org/10.1016/S1003-6326(20)65425-5
  2. Buriti, M. de S., Cézac, P., & Casás, L. (2024). Dissolution and precipitation of jarosite-type compounds: State of the art and future perspectives. Comptes Rendus Chimie, 27(S4), 81–109. https://doi.org/10.5802/crchim.321
  3. Buriti, M. de S., Poulain, M., Cézac, P., & Casás, L. (2025). K-jarosite precipitation kinetics at low-moderate temperatures: Factors affecting mechanism, formation rates, solid morphology and crystallinity. Hydrometallurgy, 235, Article 106474. https://doi.org/10.1016/j.hydromet.2025.106474
  4. Chen, Y., Liao, Y., Yu, D., Guo, X., Zhang, L., & Tian, Q. (2026). Thermal activation of hydronium alunite for selective leaching of Al and S from HPAL residue. Journal of Sustainable Metallurgy, 12(2), 2270–2283. https://doi.org/10.1007/s40831-026-01460-9
  5. Cruells, M., & Roca, A. (2022). Jarosites: Formation, structure, reactivity and environmental. Metals, 12(5), Article 802. https://doi.org/10.3390/met12050802
  6. da Silva, M. de F., de Sousa Oliveira, M. R., dos Santos, I. D., Radino-Rouse, P., & Mansur, M. B. (2022). Iron precipitation strategies from nickel laterite ore sulfuric acid leach liquor. Mineral Processing and Extractive Metallurgy Review, 43(1), 28–39. https://doi.org/10.1080/08827508.2020.1809392
  7. Das, G. K., & Li, J. (2023). Iron removal as goethite from synthetic laterite leach solutions. ACS Omega, 8(13), 11931–11940. https://doi.org/10.1021/acsomega.2c07595
  8. Deng, Z.-G., Yang, F., Wei, C., Zhu, B.-P., Zeng, P., Li, X.-B., Li, C.-X., & Li, M.-T. (2020). Transformation behavior of ferrous sulfate during hematite precipitation for iron removal. Transactions of Nonferrous Metals Society of China, 30(2), 492–500. https://doi.org/10.1016/S1003-6326(20)65229-3
  9. Dickson, O. V., Deleau, T., Espitalier, F., Coquelet, C., Lombart, J., & Nallet, V. (2026). Autoclave scaling behaviour and characterisation during nickel laterite ore leaching under HPAL conditions. Cleaner Waste Systems, 14, Article 100503. https://doi.org/10.1016/j.clwas.2026.100503
  10. Dong, B., Tian, Q., Guo, X., Wang, Q., Xu, Z., & Li, D. (2022). Leaching behavior of scandium from limonitic laterite ores under sulfation roasting–water leaching. Journal of Sustainable Metallurgy, 8(3), 1078–1089. https://doi.org/10.1007/s40831-022-00551-7
  11. Dong, B., Tian, Q., Xu, Z., Guo, X., Wang, Q., & Li, D. (2023). The effect of pre-roasting on atmospheric sulfuric acid leaching of saprolitic laterites. Hydrometallurgy, 218, Article 106063. https://doi.org/10.1016/j.hydromet.2023.106063
  12. Falah, F. N., Kurniawan, K., Ichlas, Z. T., & Mubarok, M. Z. (2026). Recovery of scandium from bauxite residue using sulfation roasting-assisted water leaching process. Mineral Processing and Extractive Metallurgy Review, 47(2), 211–225. https://doi.org/10.1080/08827508.2025.2454694
  13. Febriana, E., Hidayat, T., Fauzi, I., Irawan, J., Mayangsari, W., Rhamdani, A. R., Prasetyo, A. B., Oediyani, S., & Firdiyono, F. (2026). Iron removal from acidic limonitic laterite leach solution through controlled oxidative and alkaline precipitation. Mining, Metallurgy & Exploration, 43, 2823–2832. https://doi.org/10.1007/s42461-026-01548-6
  14. Gayratov, B., Gayratov, B., Godirilwe, L. L., Danha, G., & Shibayama, A. (2026). Waste-on-waste roasting of copper slag with flotation tailings for selective recovery of Cu, Ni, and Co. Recycling, 11(7), Article 124. https://doi.org/10.3390/recycling11070124
  15. Gontijo, V. L., Teixeira, L. A. V., & Ciminelli, V. S. T. (2020). The reactivity of iron oxides and hydroxide during low-temperature sulfation. Hydrometallurgy, 197, Article 105452. https://doi.org/10.1016/j.hydromet.2020.105452
  16. Gontijo, V. L., Teixeira, L. A. V., & Ciminelli, V. S. T. (2023). The effect of iron- and calcium-rich waste rock’s acid baking conditions on the rare-earth extraction. Minerals, 13(2), Article 217. https://doi.org/10.3390/min13020217
  17. Grudinsky, P. I., Zhiltsova, E. E., Grigorieva, D. D., & Dyubanov, V. G. (2021). Experimental study of the sulphatizing roasting of flotation tailings from copper slag processing using iron sulfates. IOP Conference Series: Earth and Environmental Science, 666(2), Article 022046. https://doi.org/10.1088/1755-1315/666/2/022046
  18. Hariyanto, R. K. S., da Rocha, L. T., Kim, S.-J., & Jung, S.-M. (2023a). Extraction behavior of nickel and cobalt from serpentine-rich ore through sulfation–roasting–leaching process. Metallurgical and Materials Transactions B, 54(6), 2915–2928. https://doi.org/10.1007/s11663-023-02934-x
  19. Hariyanto, R. K. S., da Rocha, L. T., Kim, S.-J., & Jung, S.-M. (2023b). Influence of alkali salts on extraction of nickel from serpentine-rich ore through sulfation roasting leaching Journal of Sustainable Metallurgy, 9(4), 1636–1646. https://doi.org/10.1007/s40831-023-00753-7
  20. Hariyanto, R. K. S., da Rocha, L. T., Cho, S.-K., & Jung, S.-M. (2024). Influence of SiO₂ and MgO on extraction of nickel and cobalt from laterite ores by sulfation roasting leaching process. Metallurgical and Materials Transactions B, 55(3), 1455–1470. https://doi.org/10.1007/s11663-024-03039-9
  21. Kart, E. U., Yazğan, Z. H., & Gümüşsoy, A. (2021). Investigation of iron selectivity behaviour of copper smelter slag flotation tailing with hematitization baking and base metals leaching methods. Physicochemical Problems of Mineral Processing, 57(5), 164–175. https://doi.org/10.37190/ppmp/141947
  22. Klyushnikov, A. M., Gulyaeva, R. I., Selivanov, E. N., & Pikalov, S. M. (2021). Kinetics and mechanism of oxidation for nickel-containing pyrrhotite tailings. International Journal of Minerals, Metallurgy and Materials, 28(9), 1469–1477. https://doi.org/10.1007/s12613-020-2109-x
  23. Klyushnikov, A. M., Pikalov, S. M., & Gulyaeva, R. I. (2023). Kinetics of solid-state oxidation of iron, copper and zinc sulfide mixture. Chimica Techno Acta, 10(2), Article 202310202. https://doi.org/10.15826/chimtech.2023.10.2.02
  24. Kutluata, O. B., & Obut, A. (2026). Leaching behaviour of scandium from a clayey laterite ore in sulfuric acid solutions. Physicochemical Problems of Mineral Processing, 62(1), Article 218081. https://doi.org/10.37190/ppmp/218081
  25. Lacalamita, M., Ventruti, G., Della Ventura, G., Radica, F., Mauro, D., & Schingaro, E. (2021). In situ high-temperature X-ray powder diffraction and infrared spectroscopic study of melanterite, FeSO₄·7H₂O. Minerals, 11(4), Article 392. https://doi.org/10.3390/min11040392
  26. Maluleke, K. C., Goso, X. C., Ndlovu, S., & Matinde, L. (2023). Investigations into the extraction of rare earth elements from Zandkopsdrift ore using the sulfation roasting process. Minerals Engineering, 191, Article 107902. https://doi.org/10.1016/j.mineng.2022.107902
  27. Mamyrbayeva, K., Kuandykova, A., Chepushtanova, T., Merkibayev, Y., & Mishra, B. (2026). Investigation of the sulfation-roasting-water leaching process for efficient recovery of nickel and cobalt from Kazakhstan’s laterite ore. Canadian Metallurgical Quarterly, 65(3), 1–16. https://doi.org/10.1080/00084433.2025.2603070
  28. Muhammad, A. J., Nakagawa, K., Karya, I. P. A., Ndita, A., Darusman, L. O. M., Iwamoto, T., Terui, Y., Agusu, L., Sudiana, I. N., Nishimura, F., Nishiumi, T., Asano, T., Kikuchi, H., & Mitsudo, S. (2025). Microwave-assisted roasting-leaching of nickel from Indonesian nickel laterite ore. International Journal of Acta Material, 1(2), 73–83. https://doi.org/10.62749/ijactmat.v1i2.10
  29. Osali, M., Ahani, F., Aboutalebi, M. R., Adeli, M., Moghaddam, J., Karimi, S., Wijenayake, J. J., & Alagha, L. (2026). Selective extraction of nickel and cobalt from limonitic laterite via optimized sulfation roasting–water leaching and solvent extraction. Minerals, 16(5), Article 431. https://doi.org/10.3390/min16050431
  30. Peng, X., Liu, W., Liu, W., Zhao, L., Zhang, N., Gu, X., & Zhou, S. (2021). Fluorite-enhanced magnesium recovery from serpentine tailings: Kinetics and reaction mechanisms. Hydrometallurgy, 201, Article 105571. https://doi.org/10.1016/j.hydromet.2021.105571
  31. Pereira, A. C. (2026a). Balancing nickel recovery, iron dissolution, acid dosage, and residence time in atmospheric sulfuric acid leaching of a ferruginous lateritic nickel ore. Journal International Review of Research Studies, 1(9), 1–30. https://doi.org/10.66104/dempc459.
  32. Pereira, A. C. (2026b). From mineralogy to process design: The role of particle size distribution on nickel extraction kinetics and hydrometallurgical route selection in a limonitic laterite. IKR Journal of Engineering and Technology, 2(4), 1–17. https://doi.org/10.5281/zenodo.21209619.
  33. Qin, H., Liu, P., Yu, D., Li, T., & Tian, Q. (2026). Nickel extraction from ferronickel alloy via sulfuric acid curing–oxidative decomposition roasting followed by water leaching. JOM, 78(7), 6793–6805. https://doi.org/10.1007/s11837-026-08355-w
  34. Reddy, K. V. K., Sanjana, V., Singh, V., & Kapure, G. (2020). Processing of peridotite rocks of chromite ore overburden into magnesium salts and micro silica. Mining, Metallurgy & Exploration, 37(4), 1253–1263. https://doi.org/10.1007/s42461-020-00211-y
  35. Rego, A. S. C., Marprates, C. V. B., Silva, T. S. X., Neto, J. G., Navarro, R. C. S., Souza, R. F. M., & Brocchi, E. A. (2021). KAl(SO₄)₂ thermal decomposition kinetics modeling through graphical and PSO methods. Journal of Materials Research and Technology, 14, 1975–1984. https://doi.org/10.1016/j.jmrt.2021.07.086
  36. Rego, A. S. C., Navarro, R. C. S., Brocchi, E. A., & Souza, R. F. M. (2024). Kinetic study on the thermal decomposition of iron(II) sulfate using a global optimization approach. Materials Chemistry and Physics, 327, Article 129869. https://doi.org/10.1016/j.matchemphys.2024.129869
  37. Ribeiro, P. P. M., de Souza, L. C. M., Neumann, R., dos Santos, I. D., & Dutra, A. J. B. (2020). Nickel and cobalt losses from laterite ore after the sulfation-roasting-leaching processing. Journal of Materials Research and Technology, 9(6), 12404–12415. https://doi.org/10.1016/j.jmrt.2020.08.082
  38. Ribeiro, P. P. M., dos Santos, I. D., Neumann, R., Fernandes, A., & Dutra, A. J. B. (2021). Roasting and leaching behavior of nickel laterite ore. Metallurgical and Materials Transactions B, 52(3), 1739–1754. https://doi.org/10.1007/s11663-021-02141-6
  39. Ribeiro, P. P. M., Neumann, R., dos Santos, I. D., & Dutra, A. J. B. (2022). An alternative route to extract nickel and cobalt from non-commercial laterite ore. REM – International Engineering Journal, 75(3), 245–257. https://doi.org/10.1590/0370-44672021750048
  40. Sarı, Z. A., Turan, M. D., & Nizamoğlu, H. (2026). Thermal decomposition and leaching mechanisms of copper(II) oxalate (CuC₂O₄) raw material obtained from chalcopyrite concentrate. Journal of Central South University. Advance online publication. https://doi.org/10.1007/s11771-026-6353-8
  41. ouza, R. F. M., Tavares, M. A. A., Cruz, L. E. C., Oliveira, V. A. A., Santos, I. D., Moura, F. , & Brocchi, E. A. (2022). On the cobalt content upgrade in nickeliferous laterites using iron(III) sulfate: A study based on thermodynamics simulations. Minerals, 12(9), Article 1156. https://doi.org/10.3390/min12091156
  42. Sun, Q., Cheng, H., Mei, X., Liu, Y., Li, G., Xu, Q., & Lu, X. (2020). Efficient synchronous extraction of nickel, copper, and cobalt from low-nickel matte by sulfation roasting–water leaching process. Scientific Reports, 10, Article 9916. https://doi.org/10.1038/s41598-020-66894-x
  43. Sun, Y., Sun, G., Shi, Z., Yu, Q., & Wang, L. (2026). Thermodynamic modeling of selective sulfate roasting of copper–cobalt–iron sulfide ores: Phase transformation pathways and optimal process conditions. Minerals, 16(5), Article 497. https://doi.org/10.3390/min16050497
  44. Taheri, B., & Larachi, F. (2025). Mineral-based magnesium extraction technologies: Current and future practices. Processes, 13(9), Article 2945. https://doi.org/10.3390/pr13092945
  45. Tang, Y., Jia, X., Huang, C., Wang, F., Ren, Y., Gu, W., Li, R., Zhang, G., & Tang, M. (2023). Dissolution characteristics of typical iron-containing minerals. Journal of Earth Environment, 14(2), 136–144. https://doi.org/10.7515/JEE222007
  46. Tauakelov, C. A., Rakhimbayev, B. S., Yskak, A., Valiev, K. K., Tastanov, Y. A., Ibrayev, M. K., Bulaev, A. G., Daribayeva, S. A., Kazbekova, K. A., & Joldassov, A. A. (2025). Treatment of refractory oxidized nickel ores (ONOs) from the Shevchenkovskoye ore deposit. Metals, 15(8), Article 876. https://doi.org/10.3390/met15080876
  47. Teixeira, L. A. V. (2020). Sulfation and selective roasting of rare earth elements in complex, iron-rich ores [Doctoral thesis, Universidade Federal de Minas Gerais]. Repositório Institucional da Universidade Federal de Minas Gerais. https://hdl.handle.net/1843/39620
  48. Thibault, Y., Gamage McEvoy, J., & Duguay, D. (2026). Key factors impacting the decomposition rate of REE silicates during sulfuric acid treatment. Minerals, 16(1), Article 31. https://doi.org/10.3390/min16010031
  49. Thomas, M. (2021). Understanding gangue acid consumption in copper sulfide heap leaching: Predicting the impact of carbonates, silicates and secondary precipitates. Minerals Engineering, 171, Article 107090. https://doi.org/10.1016/j.mineng.2021.107090
  50. Toro, N., Ghorbani, Y., Turan, M. D., Robles, P., & Gálvez, E. (2021). Gangues and clays minerals as rate-limiting factors in copper heap leaching: A review. Metals, 11(10), Article 1539. https://doi.org/10.3390/met11101539
  51. Urtnasan, E., Kumar, A., & Wang, J.-P. (2024). Correlation between thermodynamic studies and experimental process for roasting cobalt-bearing pyrite. Metals, 14(7), Article 777. https://doi.org/10.3390/met14070777
  52. Vehmaanperä, P., Salmimies, R., & Häkkinen, A. (2021). Thermodynamic and kinetic studies of dissolution of hematite in mixtures of oxalic and sulfuric acid. Mining, Metallurgy & Exploration, 38(1), 69–80. https://doi.org/10.1007/s42461-020-00308-4
  53. Ventruti, G., Della Ventura, G., Gomez, M. A., Capitani, G., Sbroscia, M., & Sodo, A. (2020). High-temperature study of basic ferric sulfate, FeOHSO₄. Physics and Chemistry of Minerals, 47(10), Article 43. https://doi.org/10.1007/s00269-020-01113-7
  54. Wan, X., Shi, J., Taskinen, P., & Jokilaakso, A. (2020). Extraction of copper from copper-bearing materials by sulfation roasting with SO₂–O₂ gas. JOM, 72(10), 3436–3446. https://doi.org/10.1007/s11837-020-04300-7
  55. Wan, X., Taskinen, P., Shi, J., & Jokilaakso, A. (2021). A potential industrial waste–waste co-treatment process of utilizing waste SO₂ gas and residue heat to recover Co, Ni, and Cu from copper smelting slag. Journal of Hazardous Materials, 414, Article 125541. https://doi.org/10.1016/j.jhazmat.2021.125541
  56. Wanderley, K. B., Botelho Junior, A. B., Espinosa, D. C. R., & Tenório, J. A. S. (2020). Kinetic and thermodynamic study of magnesium obtaining as sulfate monohydrate from nickel laterite leach waste by crystallization. Journal of Cleaner Production, 272, Article 122735. https://doi.org/10.1016/j.jclepro.2020.122735
  57. Xiao, F., Liu, J., Yang, C., Shen, X., Yang, Z., Luo, X., Huang, H., Sun, S., & Tu, G. (2026). Sustainable valorization of limonitic laterite via phosphoric acid leaching: Selective recovery of nickel and cobalt with co-production of iron phosphate under atmospheric conditions. Journal of Cleaner Production, 561, Article 148423. https://doi.org/10.1016/j.jclepro.2026.148423
  58. Xiao, T., Mu, W., Shi, S., Xin, H., Xu, X., Cheng, H., Luo, S., & Zhai, Y. (2021). Simultaneous extraction of nickel, copper, and cobalt from low-grade nickel matte by oxidative sulfation roasting–water leaching process. Minerals Engineering, 174, Article 107254. https://doi.org/10.1016/j.mineng.2021.107254
  59. Xu, Y.-J., Xin, H.-X., Duan, H.-M., Li, Y.-D., Wu, Y., Lin, J., & Zhai, Y.-C. (2022). Reaction behavior of silicon-rich diasporic bauxite with ammonium sulfate during roasting. Journal of Central South University, 29(1), 22–31. https://doi.org/10.1007/s11771-022-4917-9
  60. Yang, X., Gao, L., Wu, Y., Chen, Y., & Tong, L. (2022). Extraction of magnesium and nickel from nickel-rich serpentine with sulfation roasting and water leaching. Metals, 12(2), Article 318. https://doi.org/10.3390/met12020318
  61. Yeskibayeva, C., Auyeshov, A., Arynov, K., Dikanbayeva, A., & Satimbekova, A. (2024). Nature of serpentinite interactions with low-concentration sulfuric acid solutions. Green Processing and Synthesis, 13(1), Article 20240034. https://doi.org/10.1515/gps-2024-0034
  62. Zhang, X., Wang, X., Guo, F., Hu, Y., Wu, J., Fan, W., Cui, J., Li, N., Zang, L., & Ma, R. (2026). Role of magnetite in high-temperature sulfuric acid roasting of Bayan Obo REE concentrate. JOM. Advance online publication. https://doi.org/10.1007/s11837-026-08192-x .
  63. Zhao, Z., Li, H., & Wang, C. (2025). An integrated sulfation-roasting-leaching process for coextraction of nickel and cobalt from laterite ores with enhanced SO₃ recovery. ACS Sustainable Resource Management, 2(1), 201–211. https://doi.org/10.1021/acssusresmgt.4c00437.
  64. Zhao, Z., Li, H., Wang, C., & Xing, P. (2025b). Selective and efficient extraction of nickel and cobalt from laterite ores using the sulfation-roasting and leaching-precipitation process with H₂O₂ and surfactant addition. Hydrometallurgy, 237, Article 106546. https://doi.org/10.1016/j.hydromet.2025.106546.
  65. Zheng, G., Xia, J., Chen, Z., Yang, J., & Liu, C. (2020). Study on kinetics of the pyrolysis process of aluminum sulfate. Phosphorus, Sulfur, and Silicon and the Related Elements, 195(4), 285–292. https://doi.org/10.1080/10426507.2019.1686377.

Author's Affiliation

   Antonio Clareti Pereira, PhD
PhD in Chemical Engineering University of São Paulo (USP), Belo Horizonte, Minas Gerais, Brazil ORCID: https://orcid.org/0000-0001-8115-4279

Copyrights & License

Antonio Clareti Pereira, PhD, 2026

This work is licenced under a Creative Commons Attribution 4.0 International License.

Article Details

How to Cite :

Selective Iron Suppression through Sulfation, Oxidative Calcination, and pH-Controlled Atmospheric Leaching of a Ferruginous Oxidized Copper Ore. Antonio Clareti Pereira , 9(7), 4155-4175. Retrieved from https://ijcsrr.org/single-view/?id=27107&pid=26792

Most read articles by the same author(s)

Antonio Clareti Pereira, PhD,

View

5

Citation

Downloads

Article Details